JGH臺灣久岡4WE-10-J/E-G24-20 E/D/G/R W240/W220/50 JEOU GANG

液壓泵站系統油缸轉向故障分析與排除方法

液壓站采用液壓轉向，不但結構簡單，還有利于轉向液壓系統操作和維護，大大提高了液壓機器的可操縱性和駕駛舒適性。然而，在液壓油從油缸到工作元件的過程中，任何環節出現問題，對分析、排除轉向故障，制定對策非常重要。下面跟大家談下液壓泵站的一些故障和排除方法。

1、液壓油泵

首先要保證給液壓油泵足夠的輸入動力，定期檢查油泵固定是否牢固可靠，皮帶張緊力是否合適，及時觀察液壓泵的輸出壓力。如果液壓泵輸出壓力突然下降，應停車檢查，以免因泵卡死或磨損燒蝕而造成更大的損失。泵的齒頂與殼體內孔配合間隙爲0.05~0.1mm，軸向間隙爲0.03~0.05mm。

2、液壓油缸

油缸內的液壓油應加注至規定高度，同時油缸閥門開度應足夠大，以避免供油不足。液壓油型號應按規定加注，不能不同型號液壓油混加，以免引起油品變質，使抗泡性、粘度、流動性能下降，液壓油缸要保持高度清潔，定期清洗過濾網，以避免吸油阻力過大，加劇泵和液壓油缸的磨損。

3、轉向液壓缸

油缸出現問題的現象肉眼能看到漏油，或機器在不平的路上行走時，前輪會自動的“到處亂跑”。其主要原因就是油缸內活塞上的油封漏油。此時，應按照産品型號換上合格的油封，并確保裝配時高度清潔，同時保證活塞上的兩個油封唇口都向外，問題即可解決。當轉向機構出現故障時，然后根據各部件的維修標準，進行認真細緻的維修，一般都能解決問題。

電磁換向閥：
4WE-10A/E-G24-20 4WE-10A/E-W110-20 4WE-10A/E-W220-20 4WE-10A/E-W240-20 4WE-10B/E-G24-20 4WE-10B/E-W110-20
4WE-10B/E-W220-20 4WE-10B/E-W240-20 4WE-10C/E-G24-20 4WE-10C/E-W110-20 4WE-10C/E-W220-20 4WE-10C/E-W240-20
4WE-10D/E-G24-20 4WE-10D/E-W110-20 4WE-10D/E-W220-20 4WE-10D/E-W240-20 4WE-10E/E-G12-20 4WE-10E/E-W110-20
4WE-10E/E-W240-20 4WE-10F/E-G12-20 4WE-10F/E-W110-20 4WE-10F/E-W240-20 4WE-10G/E-G12-20 4WE-10G/E-W110-20
4WE-10G/E-W240-20 4WE-10P/E-W240-20 4WE-10V/E-W240-20 4WE-6-A/E-G12-20 4WE-6-A/E-G24-20 4WE-6-A/E-W110-20
4WE-6-A/E-W220-20 4WE-6-A/E-W240-20 4WE-6-AO/E-G12-20 4WE-6-AO/E-G24-20 4WE-6-AO/E-W110-20
4WE-6-AO/E-W220-20 4WE-6-AO/E-W240-20 4WE-6-AOF/E-G12-20 4WE-6-AOF/E-G24-20 4WE-6-AOF/E-W110-20
4WE-6-AOF/E-W220-20 4WE-6-AOF/E-W240-20 4WE-6-B/E-G12-20 4WE-6-B/E-G24-20 4WE-6-B/E-W110-20 4WE-6-B/E-W220-20
4WE-6-B/E-W240-20 4WE-6-BO/E-G12-20 4WE-6-BO/E-G24-20 4WE-6-BO/E-W110-20 4WE-6-BO/E-W220-20
4WE-6-BO/E-W240-20 4WE-6-BOF/E-G12-20 4WE-6-BOF/E-G24-20 4WE-6-BOF/E-W110-20 4WE-6-BOF/E-W220-20
4WE-6-BOF/E-W240-20 4WE-6-C/E-G12-20 4WE-6-C/E-G24-20 4WE-6-C/E-W110-20 4WE-6-C/E-W220-20 4WE-6-C/E-W240-20
4WE-6-CO/E-G12-20 4WE-6-CO/E-G24-20 4WE-6-CO/E-W110-20 4WE-6-CO/E-W220-20 4WE-6-CO/E-W240-20
4WE-6-COF/E-G12-20 4WE-6-COF/E-G24-20 4WE-6-COF/E-W110-20 4WE-6-COF/E-W220-20 4WE-6-COF/E-W240-20
4WE-6-D/E-G12-20 4WE-6-D/E-G24-20 4WE-6-D/E-W110-20 4WE-6-D/E-W220-20 4WE-6-D/E-W240-20 4WE-6-DO/E-G12-20
4WE-6-DO/E-G24-20 4WE-6-DO/E-W110-20 4WE-6-DO/E-W220-20 4WE-6-DO/E-W240-20 4WE-6-DOF/E-G12-20
4WE-6-DOF/E-G24-20 4WE-6-DOF/E-W110-20 4WE-6-DOF/E-W220-20 4WE-6-DOF/E-W240-20 4WE-6-E/E-G12-20
4WE-6-E/E-G24-20 4WE-6-E/E-W110-20 4WE-6-E/E-W220-20 4WE-6-E/E-W240-20 4WE-6-EO/E-G12-20 4WE-6-EO/E-G24-20
4WE-6-EO/E-W110-20 4WE-6-EO/E-W240-20 4WE-6-EOF/E-G12-20 4WE-6-EOF/E-G24-20 4WE-6-EOF/E-W110-20
4WE-6-EOF/E-W220-20 4WE-6-EOF/E-W240-20 4WE-6-F/E-G12-20 4WE-6-F/E-G24-20 4WE-6-F/E-W110-20 4WE-6-F/E-W220-20
4WE-6-F/E-W240-20 4WE-6-FO/E-G12-20 4WE-6-FO/E-G24-20 4WE-6-FO/E-W110-20 4WE-6-FO/E-W220-20
4WE-6-FO/E-W240-20 4WE-6-FOF/E-G12-20 4WE-6-FOF/E-G24-20 4WE-6-FOF/E-W110-20 4WE-6-FOF/E-W220-20
4WE-6-FOF/E-W240-20 4WE-6-G/E-G12-20 4WE-6-G/E-G24-20 4WE-6-G/E-W110-20 4WE-6G/E-W220/50-20 4WE-6-G/E-W220-20
4WE-6-G/E-W240-20 4WE-6-GO/E-G12-20 4WE-6-GO/E-G24-20 4WE-6-GO/E-W110-20 4WE-6-GO/E-W220-20
4WE-6-GO/E-W240-20 4WE-6-GOF/E-G12-20 4WE-6-GOF/E-G24-20 4WE-6-GOF/E-W110-20 4WE-6-GOF/E-W220-20
4WE-6-GOF/E-W240-20 4WE-6-H/E-G12-20 4WE-6-H/E-G24-20 4WE-6-H/E-W110-20 4WE-6-H/E-W220-20 4WE-6-H/E-W240-20
4WE-6-HA/E-W240-20 4WE-6-HO/E-G12-20 4WE-6-HO/E-G24-20 4WE-6-HO/E-W110-20 4WE-6-HO/E-W220-20
4WE-6-HO/E-W240-20 4WE-6-HOF/E-G12-20 4WE-6-HOF/E-G24-20 4WE-6-HOF/E-W110-20 4WE-6-HOF/E-W220-20
4WE-6-HOF/E-W240-20 4WE-6-J/E-G12-20 4WE-6-J/E-G24-20 4WE-6-J/E-W110-20 4WE-6-J/E-W220/50-20 4WE-6-J/E-W220-20
4WE-6-J/E-W240-20 4WE-6-JO/E-G12-20 4WE-6-JO/E-G24-20 4WE-6-JO/E-W110-20 4WE-6-JO/E-W220-20
4WE-6-JO/E-W240-20 4WE-6-JOF/E-G12-20 4WE-6-JOF/E-G24-20 4WE-6-JOF/E-W110-20 4WE-6-JOF/E-W220-20
4WE-6-JOF/E-W240-20 4WE-6-L/E-G12-20 4WE-6-L/E-G24-20 4WE-6-L/E-W110-20 4WE-6-L/E-W220-20 4WE-6-L/E-W240-20
4WE-6-LO/E-G12-20 4WE-6-LO/E-G24-20 4WE-6-LO/E-W110-20 4WE-6-LO/E-W220-20 4WE-6-LO/E-W240-20
4WE-6-LOF/E-G12-20 4WE-6-LOF/E-G24-20 4WE-6-LOF/E-W110-20 4WE-6-LOF/E-W220-20 4WE-6-LOF/E-W240-20
4WE-6-M/E-G12-20 4WE-6-M/E-G24-20 4WE-6-M/E-W110-20 4WE-6-M/E-W220-20 4WE-6-M/E-W240-20 4WE-6-MO/E-G12-20
4WE-6-MO/E-G24-20 4WE-6-MO/E-W110-20 4WE-6-MO/E-W220-20 4WE-6-MO/E-W240-20 4WE-6-MOF/E-G12-20
4WE-6-MOF/E-G24-20 4WE-6-MOF/E-W110-20 4WE-6-MOF/E-W220-20 4WE-6-MOF/E-W240-20 4WE-6-P/E-G12-20
4WE-6-P/E-G24-20 4WE-6-P/E-W110-20 4WE-6-P/E-W220-20 4WE-6-P/E-W240-20 4WE-6-PO/E-G12-20 4WE-6-PO/E-G24-20
4WE-6-PO/E-W110-20 4WE-6-PO/E-W220-20 4WE-6-PO/E-W240-20 4WE-6-POF/E-G12-20 4WE-6-POF/E-G24-20
4WE-6-POF/E-W110-20 4WE-6-POF/E-W220-20 4WE-6-POF/E-W240-20 4WE-6-Q/E-G12-20 4WE-6-Q/E-G24-20
4WE-6-Q/E-W110-20 4WE-6-Q/E-W220-20 4WE-6-Q/E-W240-20 4WE-6-QO/E-G12-20 4WE-6-QO/E-G24-20
4WE-6-QO/E-W110-20 4WE-6-QO/E-W220-20 4WE-6-QO/E-W240-20 4WE-6-R/E-G12-20 4WE-6-R/E-G24-20 4WE-6-R/E-W110-20
4WE-6-R/E-W220-20 4WE-6-R/E-W240-20 4WE-6-RO/E-G12-20 4WE-6-RO/E-G24-20 4WE-6-RO/E-W110-20 4WE-6-RO/E-W220-20
4WE-6-RO/E-W240-20 4WE-6-ROF/E-G12-20 4WE-6-ROF/E-G24-20 4WE-6-ROF/E-W110-20 4WE-6-ROF/E-W220-20
4WE-6-ROF/E-W240-20 4WE-6-T/E-G12-20 4WE-6-T/E-G24-20 4WE-6-T/E-W110-20 4WE-6-T/E-W220-20 4WE-6-T/E-W240-20
4WE-6-TO/E-G12-20 4WE-6-TO/E-G24-20 4WE-6-TO/E-W110-20 4WE-6-TO/E-W220-20 4WE-6-TO/E-W240-20
4WE-6-TOF/E-G12-20 4WE-6-TOF/E-G24-20 4WE-6-TOF/E-W110-20 4WE-6-TOF/E-W220-20 4WE-6-TOF/E-W240-20
4WE-6-U/E-G12-20 4WE-6-U/E-G24-20 4WE-6-U/E-W110-20 4WE-6-U/E-W220-20 4WE-6-U/E-W240-20 4WE-6-UO/E-G12-20
4WE-6-UO/E-G24-20 4WE-6-UO/E-W110-20 4WE-6-UO/E-W220-20 4WE-6-UO/E-W240-20 4WE-6-UOF/E-G12-20
4WE-6-UOF/E-G24-20 4WE-6-UOF/E-W110-20 4WE-6-UOF/E-W220-20 4WE-6-UOF/E-W240-20 4WE-6-V/E-G12-20
4WE-6-V/E-G24-20 4WE-6-V/E-W110-20 4WE-6-V/E-W220-20 4WE-6-V/E-W240-20 4WE-6-VO/E-G12-20 4WE-6-VO/E-G24-20
4WE-6-VO/E-W110-20 4WE-6-VO/E-W220-20 4WE-6-VO/E-W240-20 4WE-6-VOF/E-G12-20 4WE-6-VOF/E-G24-20
4WE-6-VOF/E-W110-20 4WE-6-VOF/E-W220-20 4WE-6-VOF/E-W240-20 4WE-6-Y/E-G12-20 4WE-6-Y/E-G24-20
4WE-6-Y/E-W110-20 4WE-6-Y/E-W220-20 4WE-6-Y/E-W240-20 4WE-6-YO/E-G12-20 4WE-6-YO/E-G24-20 4WE-6-YO/E-W110-20
4WE-6-YO/E-W220-20 4WE-6-YO/E-W240-20 4WE-6-YOF/E-G12-20 4WE-6-YOF/E-G24-20 4WE-6-YOF/E-W110-20
4WE-6-YOF/E-W220-20 4WE-6-YOF/E-W240-20 4WE-Q-QOF/E-G12-20 4WE-Q-QOF/E-G24-20 4WE-Q-QOF/E-W110-20
4WE-6-QOF/E-W220-20 4WE-Q-QOF/E-W240-20
液控方向閥：
DHG-04-2B2-ET-50-W110-10-AB-K DHG-04-2B2-ET-50-W240-10-AB-K DHG-04-2B3-ET-50-W110-10-AB-K
DHG-04-2B3-ET-50-W240-10-AB-K DHG-04-2D2-ET-50-W110-10-AB-K DHG-04-2D2-ET-50-W240-10-AB-K
DHG-04-2D3-ET-50-W110-10-AB-K DHG-04-2D3-ET-50-W240-10-AB-K DHG-04-3C2-ET-50-W110-10-AB-K
DHG-04-3C2-ET-50-W240-10-AB-K DHG-04-3C3-ET-50-W110-10-AB-K DHG-04-3C3-ET-50-W240-10-AB-K
DHG-04-3C4-ET-50-W110-10-AB-K DHG-04-3C4-ET-50-W240-10-AB-K DHG-04-3C5-ET-50-W110-10-AB-K
DHG-04-3C5-ET-50-W240-10-AB-K DHG-04-3C6-ET-50-W110-10-AB-K DHG-04-3C6-ET-50-W240-10-AB-K 
DHG-04-2B10B DHG-04-2B11A DHG-04-2B11B DHG-04-2B12A DHG-04-2B12B DHG-04-2B2 DHG-04-2B2A
DHG-04-2B2B DHG-04-2B2-ET-50-W110-10-AB-K DHG-04-2B2-ET-50-W240-10-AB-K DHG-04-2B2S DHG-04-2B3
DHG-04-2B3A DHG-04-2B3B DHG-04-2B3-ET-50-W110-10-AB-K DHG-04-2B3-ET-50-W240-10-AB-K DHG-04-2B3S
DHG-04-2B40A DHG-04-2B40B DHG-04-2B4A DHG-04-2B4B DHG-04-2B5A DHG-04-2B5B DHG-04-2B60A DHG-04-2B60B
DHG-04-2B6A DHG-04-2B6B DHG-04-2B8 DHG-04-2B8S DHG-04-2B9A DHG-04-2B9B DHG-04-2D2-ET-50-W110-10-AB-K
DHG-04-2D2-ET-50-W240-10-AB-K DHG-04-2D3-ET-50-W110-10-AB-K DHG-04-2D3-ET-50-W240-10-AB-K
DHG-04-2N2 DHG-04-2N3 DHG-04-3C10-50 DHG-04-3C11-50 DHG-04-3C12-50 DHG-04-3C2 DHG-04-3C2-50
DHG-04-3C2-ET-50-W110-10-AB-K DHG-04-3C2-ET-50-W240-10-AB-K DHG-04-3C3-50 DHG-04-3C3-ET-50-W110-10-AB-K
DHG-04-3C3-ET-50-W240-10-AB-K DHG-04-3C40-50 DHG-04-3C4-50 DHG-04-3C4-ET-50-W110-10-AB-K
DHG-04-3C4-ET-50-W240-10-AB-K DHG-04-3C5-50 DHG-04-3C5-ET-50-W110-10-AB-K DHG-04-3C5-ET-50-W240-10-AB-K
DHG-04-3C60-50 DHG-04-3C6-50 DHG-04-3C6-ET-50-W110-10-AB-K DHG-04-3C6-ET-50-W240-10-AB-K DHG-04-3C9-50
DHG-06-2B10B DHG-06-2B11A DHG-06-2B11B DHG-06-2B12A DHG-06-2B12B DHG-06-2B2 DHG-06-2B2A
DHG-06-2B2B DHG-06-2B2S DHG-06-2B3 DHG-06-2B3A DHG-06-2B3B DHG-06-2B3S DHG-06-2B40A DHG-06-2B40B
DHG-06-2B4A DHG-06-2B4B DHG-06-2B5A DHG-06-2B5B DHG-06-2B60A DHG-06-2B60B DHG-06-2B6A DHG-06-2B6B
DHG-06-2B8 DHG-06-2B8S DHG-06-2B9A DHG-06-2B9B DHG-06-2N2 DHG-06-2N3 DHG-06-3C10-50 DHG-06-3C11-50
DHG-06-3C12-50 DHG-06-3C2-50 DHG-06-3C3-50 DHG-06-3C40-50 DHG-06-3C4-50 DHG-06-3C5-50 DHG-06-3C60-50
DHG-06-3C6-50 DHG-06-3C9-50 DHG-10-2B10B DHG-10-2B11B DHG-10-2B12B DHG-10-2B2B DHG-10-2B3B
DHG-10-2B40B DHG-10-2B4B DHG-10-2B5B DHG-10-2B60B DHG-10-2B6B DHG-10-2B9B DHG-10-2N2 DHG-10-2N3
DHG-10-3C10-50 DHG-10-3C11-50 DHG-10-3C12-50 DHG-10-3C2-50 DHG-10-3C3-50 DHG-10-3C40-50 DHG-10-3C4-50
DHG-10-3C5-50 DHG-10-3C60-50 DHG-10-3C6-50 DHG-10-3C9-50
S-DSHG-10-3H60A220 S-DSHG-10-3H60-A220 S-DSHG-10-3H60-E-D24
抗衡閥：
J-CBEA-1-L J-PBC-A-L J-PBC-B-L J-PBC-D-L J-PBE-A-L J-PBE-B-L J-PBE-D-L J-PBG-A-L J-PBG-B-L J-PBG-D-L
溢流閥：
MRV-02-A-1-A-K MRV-02-A-1-B-K MRV-02-B-1-A-K MRV-02-B-1-B-K MRV-02-B-2-B MRV-02-P-1-A-K MRV-02-P-1-B
MRV-02-P-1-B-K MRV-02-P-3-B MRV-03-A-2-B-K MRV-03-A-2-B-L MRV-03-B-2-B-K MRV-03-B-2-B-L MRV-03-B-3-B
MRV-03-P-2-B-K MRV-03-P-2-B-L MRV-03-P-3-B MSCV-03-A-3-B
電磁控制溢流閥：
SBSG-03-1PN-1-L-30-10 SBSG-03-1PN-1-R-30-10 SBSG-03-1PN-2-L-30-10 SBSG-03-1PN-2-R-30-10 SBSG-03-1PN-3-L-30-10
SBSG-03-1PN-3-R-30-10 SBSG-06-1PN-1-L-30-10 SBSG-06-1PN-1-R-30-10 SBSG-06-1PN-2-L-30-10 SBSG-06-1PN-2-R-30-10
SBSG-06-1PN-3-L-30-10 SBSG-06-1PN-3-R-30-10 SBSG-10-1PN-1-L-30-10 SBSG-10-1PN-1-R-30-10 SBSG-10-1PN-2-L-30-10
SBSG-10-1PN-2-R-30-10 SBSG-10-1PN-3-L-30-10 SBSG-10-1PN-3-R-30-10