油昇YEOSHE油泵V70/V50/V40/V38/V25/V23/V18/V15A4R10X/A3/A2/A1

液壓油泵的調試及注意事項

一臺新的液壓系統組裝完成后一般都要經過調試好后才能投入工作，今天主要跟大家講下液壓油泵的調試方法與注意要點。 液壓油泵安裝完成后，必須經過泵的檢查，調試，觀察泵的工作是否正常，那如何去檢查、調試液壓泵是否工作正常呢？ 下面一起來看看吧！

(1)檢查油泵的旋轉方向應與泵體上標牌所指示的方向相符合，不得接反。

(2)用手轉動聯軸節，應感輕快，受力均勻，以識別泵的安裝是否正常。

(3)檢查系統中的安全閥是否在調定的許可壓力上。

(4)檢查液壓系統有沒有卸荷回路，能否造成滿載啓動和停車，以至降低泵的使用壽命，并使電機過載。

(5)油泵首次試車前，應在排油口灌滿油液，使泵內有油，以免泵啓動時因干摩擦損壞元件，同時將安全閥打開。

(6)油泵在工作前應進行不少于10min的空負荷運轉.檢查泵的運轉聲音是否正常和液流的方向是否正確。如果正常，則可進行帶負荷試車。首先進行低負荷運轉，將溢流閥的壓力調整到2.0MPa以下轉動10一15min,檢查系統的動作、外洩漏、噪聲、溫升等是否正常。如果一切正常，可將溢流閥的壓力調整至液壓系統的安全保護壓力，再使液壓系統卸荷。若不正常，則查找原因，再做調試和試車，直到油泵正常工作爲止。

柱塞泵：
AR16-FL01B-K10Y AR16-FL01B-S-K10Y AR16-FL01C-K10Y AR16-FL01C-S-K10Y AR16-FR01B-20 AR16-FR01B-K10Y
AR16-FR01B-S-K10Y AR16-FR01C-20 AR16-FR01C-K10Y AR16-FR01C-S-K10Y AR22-FL01B-K10Y AR22-FL01B-S-K10Y
AR22-FL01C-K10Y AR22-FL01C-S-K10Y AR22-FR01B-20 AR22-FR01B-K10Y AR22-FR01B-S-K10Y AR22-FR01C-K10Y
AR22-FR01C-S-K10Y
單向閥：
CIT-03-A2 CIT-04-A1 CIT-04-A2 CIT-06-A1 CIT-06-A2 CIT-08-A1 CIT-08-A2 CIT-10
CIT-10-A1 CIT-10-A2 CIT-12-A1 CIT-12-A2 CIT-16-A1 CIT-16-A2
液控單向閥：
CPDG-03-30-20 CPDG-03-30-E-20 CPDG-03-50-20 CPDG-03-50-E-20 CPDG-03-75-20 CPDG-03-75-E-20 CPDG-06-30-20
CPDG-06-30-E-20 CPDG-06-50-20 CPDG-06-50-E-20 CPDG-06-75-20 CPDG-06-75-E-20
CPDT-03-30-20 CPDT-03-30-E-20 CPDT-03-50-20 CPDT-03-50-E-20 CPDT-03-75-20 CPDT-03-75-E-20 CPDT-06-30-20
CPDT-06-30-E-20 CPDT-06-50-20 CPDT-06-50-E-20 CPDT-06-75-20 CPDT-06-75-E-20
CPG-03 CPG-03-30-20 CPG-03-30-E-20 CPG-03-50-20 CPG-03-50-E-20 CPG-03-75-20 CPG-03-75-E-20 CPG-03-E CPG-06
CPG-06-30-20 CPG-06-30-E-20 CPG-06-50-20 CPG-06-50-E-20 CPG-06-75-20 CPG-06-75-E-20 CPG-06-E CPG-10-E
CPT-03-30-20 CPT-03-30-E-20 CPT-03-50-20 CPT-03-50-E-20 CPT-03-75-20 CPT-03-75-E-20 CPT-06-30-20 CPT-06-30-E-20
CPT-06-50-20 CPT-06-50-E-20 CPT-06-75-20 CPT-06-75-E-20
CRG-03-A2 CRG-06-A2 CRG-10-A1 CRG-10-A2 CRNG-03-A1 CRNG-03-A2 CRNG-06-A1 CRNG-06-A2 CRNG-10-A1 CRNG-10-A2
機械式換向閥：
DCG-02 DCG-02-NC DCG-02-NO
DCT-02
手動換向閥：
DMG-10-2B2-40 DMG-10-2B40-40 DMG-10-2B4-40 DMG-10-2B7-40 DMG-10-2D4-40 DMG-10-2D7-40 DMG-10-3C12-40
電磁換向閥：
DSG-01-2B12B-D24-50-L DSG-01-2B2 DSG-01-2B2-A110-50 DSG-01-2B2-A220-50 DSG-01-2B2-A220-70 DSG-01-2B2B-A220-50
DSG-01-2B2B-A220-50  DSG-01-2B2B-D24-50 DSG-01-2B2-D24-70 DSG-01-2B3B-A220-50 DSG-01-2B3B-A220-50(Y)
DSG-01-2B3B-A220-N1-50 DSG-01-2B3B-D24-50 DSG-01-2B3B-D24V DSG-01-2B3-D24-50 DSG-01-2D2 DSG-01-2D2-D24-50
DSG-01-2D2-D24-70 DSG-01-3C2 DSG-01-3C2-A110-50 DSG-01-3C2-D24-N-70 DSG-01-3C4 DSG-01-3C4-A110-50
DSG-01-3C4-A240-70 DSG-01-3C4-D24-50 DSG-01-3C4-D24-70 DSG-01-3C60 DSG-03-2B2 DSG-03-2B2-A110-50
DSG-03-2B2-A200-50 DSG-03-2B2-A220-D24-50 DSG-03-2B2-A220-N1-50 DSG-03-2B2B-A220-50 DSG-03-2B2-D24-50-L
DSG-03-2B3-A110-50 DSG-03-2D2 DSG-03-2D2-A110-50 DSG-03-2D2-A220-N1-50 DSG-03-2D2-D24-50 DSG-03-3C2
DSG-03-3C2-A110-50 DSG-03-3C2-A220-50 DSG-03-3C2-A220-N-50 DSG-03-3C2-A240-N1-50 DSG-03-3C2-D24-50
DSG-03-3C2-D24-N-70 DSG-03-3C2-R220-50 DSG-03-3C4 DSG-03-3C40-D24-50 DSG-03-3C4-A110-50 DSG-03-3C4-A220-50
DSG-03-3C4-A220-N1-50 DSG-03-3C4-D24-50 DSG-03-3C60 DSG-03-3C60-A110-50 DSG-03-3C60-A220-50 DSG-03-3C60-A220-N-50 DSG-03-3C60-D24-50
電液換向閥：
DSHG-06-3C2-A220-50
溢流閥：
DT-01-22
疊加式單向閥：
MCA-03 MCB-03 MCP-01 MCP-03 MCT-03 MPA-01 MPA-03 MPB-01 MPB-03 MPW-01 MPW-03 MSW-01-X-30 MSW-03-X-30
葉片泵：
PV016-A1-R PV016-A2-R PV016-A3-R PV016-A4-R PV020-A1-R PV020-A2-R PV020-A3-R PV020-A4-R PV023-A1-R PV023-A2-R
PV023-A3-R PV023-A4-R PV032-A1-R PV032-A2-R PV032-A3-R PV032-A4-R PV040-A1-R PV040-A2-R PV040-A3-R PV040-A4-R
PV046-A1-R PV046-A2-R PV046-A3-R PV046-A4-R PV063-A1-R PV063-A2-R PV063-A3-R PV063-A4-R PV071-A1-R PV071-A2-R
PV071-A3-R PV071-A4-R PV080-A1-R PV080-A2-R PV080-A3-R PV080-A4-R PV092-A1-R PV092-A2-R PV092-A3-R PV092-A4-R
PV140-A1-R PV140-A2-R PV140-A3-R PV140-A4-R PV180-A1-R PV180-A2-R PV180-A3-R PV180-A4-R PV270-A1-R PV270-A2-R
PV270-A3-R PV270-A4-R
柱塞泵：
V15-15 V15-15-A1-L V15-15-A1-R V15-15-A2-L V15-15-A2-R V15-15-A3-L V15-15-A3-R V15-15-A4-L V15-15-A4-R V15-38
V15-38-A1-L V15-38-A1-R V15-38-A2-L V15-38-A2-R V15-38-A3-L V15-38-A3-R V15-38-A4-L V15-38-A4-R V15-70 V15-70-A1-L
V15-70-A1-R V15-70-A2-L V15-70-A2-R V15-70-A3-L V15-70-A3-R V15-70-A4-L V15-70-A4-R
V15-A1-L V15A1L10X V15-A1-R V15A1R10X V15-A2-L V15A2L10X V15-A2-R V15A2R10X V15-A3-L V15A3L10X V15-A3-R
V15A3R10X V15-A4-L V15A4L10X V15A1R10X V15A2R10X V15A3R10X V15A4R10X V18A1R10X V18A2R10X V18A3R10X
V18A4R10X V23A1R10X V23A2R10X V23A3R10X V23A4R10X
V15-A4-R V15A4R10X
V18-A1-L V18A1L10X V18-A1-R V18A1R10X V18-A2-L V18A2L10X V18-A2-R V18A2R10X V18-A3-L V18A3L10X
V18-A3-R V18A3R10X V18-A4-L V18A4L10X V18-A4-R V18A4R10X
V23-23 V23-23-A1-L V23-23-A1-R V23-23-A2-L V23-23-A2-R
V23-23-A3-L V23-23-A3-R V23-23-A4-L V23-23-A4-R V23-A1-L V23A1L10X V23-A1-R V23A1R10X V23-A2-L V23A2L10X
V23-A2-R V23A2R10X V23-A3-L V23A3L10X V23-A3-R V23A3R10X V23-A4-L V23A4L10X V23-A4-R V23A4R10X
V25-A1-L V25A1L10X V25-A1-R V25A1R10X V25-A2-L V25A2L10X V25-A2-R V25A2R10X V25-A3-L V25A3L10X V25-A3-R V25A3R10X
V25-A4-L V25A4L10X V25-A4-R V25A4R10X
V38-38 V38-38-A1-L V38-38-A1-R V38-38-A2-L V38-38-A2-R V38-38-A3-L V38-38-A3-R V38-38-A4-L V38-38-A4-R V38-70
V38-70-A1-L V38-70-A1-R V38-70-A2-L V38-70-A2-R V38-70-A3-L V38-70-A3-R V38-70-A4-L V38-70-A4-R V38-A1-L V38A1L10X
V38-A1-R V38A1R10X V38-A2-L V38A2L10X V38-A2-R V38A2R10X V38-A3-L V38A3L10X V38-A3-R V38A3R10X V38-A4-L V38A4L10X
V38-A4-R V38A4R10X
V42-A1-L V42A1L10X V42-A1-R V42A1R10X V42-A2-L V42A2L10X V42-A2-R V42A2R10X V42-A3-L V42A3L10X V42-A3-R
V42A3R10X V42-A4-L V42A4L10X V42-A4-R V42A4R10X
V50-A1-L V50A1L10X V50-A1-R V50A1R10X V50-A2-L V50A2L10X V50-A2-R V50A2R10X V50-A3-L V50A3L10X V50-A3-R
V50A3R10X V50-A4-L V50A4L10X V50-A4-R V50A4R10X
V70-A1-L V70A1L10X V70-A1-R V70A1R10X V70-A2-L V70A2L10X V70-A2-R V70A2R10X V70-A3-L V70A3L10X V70-A3-R
V70A3R10X V70-A4-L V70A4L10X V70-A4-R V70A4R10X